Hauler:
4X4 175” Wheelbase, highest trim level offered when ordered new in 2019. Produces 585HP / 1080 FT LBS.
Build completed in April of 2021 by Wehrli Custom Fabrication and only used during the summer months to haul our enclosed trailer. Currently has 14,4XX miles. Never seen salt or winter.
Full YouTube Build Series on Truck here: https://www.youtube.com/playlist?list=PLOGtDaXWu9KPvASGcjwEOwX_4dyxpqXrM
Upgrade List:
Kelderman Suspension Front and Rear 4 Link Air Ride System
Factory GM-installed Air System, Belt Driven Compressor
Kelderman Raptor Remote Rez Shocks All Around
Dual steering Stabilizer Kit
Completely Custom Powder Coated
Kelderman Bravo Front Bumper with 4 Rigid + Center Light Bar
Calibrated Power Solutions Tuning
Calibrated Power Solutions Stealth 64 Upgraded Turbo
UTILITY BODYWERKS Elite 60” CA Aluminum Body, Professionally Painted to Match Truck
B&W Turnover Ball
Dual Fuel Doors (OEM 26 Gal AND 40 Gal rear fuel tank)
Fabricated Rear Bumper
4 Rigid D Series Lights in Rear Bumper
Light Pylon with 2 Rigid SR-Q Flood Lights
Stainless Accent Trim
Aluminum Fabricated Side Entry Step Running Boards with LED Strips w/ Turn, Marker and Courtesy Light, PPF Film, Alum Step Tread
Factory Back Up Camera Installed
LED Work Light
Diamond Plate Floor with spray on bedliner
Stainless Hinges and Handles
2.5” Receiver Hitch
20 Gallon Air Tank Mounted in Center Storage Compartment
Flexzilla 50 ft Air Hose Reel Mounted in Passenger Compartment
Katskinz Leather Seat Covers
WeatherTech Floor Mats
GM Carpet Kit (Replaced OE Rubber Floor)
Window Tint
EDGE CTS Monitor
Horn Blasters AH-C5 Admiral Horn Kit, Powder Coated (Uses on board air system)
37” Toyo Open County AT Tires
22.5” Accuride Aluminum wheels, Custom Machined Lip to 22” to accept 37x22 Tire, Professional Polished
TRAILER:
Purchased new in April 2017 and has been used every summer since (Except for 2020) for hauling a 6500lbs pulling truck and polaris ranger. ONLY used in summer averaging about 3,000 miles per season, stored indoors and never been in salt or snow. Would work great for pulling truck or tractor + pit vehicle, or offroad truck, SxS's, Dirt track car etc.
We (Wehrli Custom Fabrication) made some custom modifications to the trailer after purchase including HD Ramp over platforms 12" off of the floor and over the fenders (only 82" between fenders) and designed a stronger rear ramp to support the weight of pulling truck coming in and out.
PM service beginning of every season, 6 new tires and fresh polish on wheels in beginning of 2023 season. Have a new full spare mounted in neck.
The trailer is Medium Charcoal Grey Exterior, the black back half and ramp door is 3M wrap. The whole trailer was professionally ceramic coated in 2019. Interior finish is Silver Frost.
Here are the build details and other important specs:
44’ long 8.5’ wide
11’ tall overall, inside height from aluminum plank floor is 8.5’ and from ramp over to ceiling is 7.5’
Inside length from the front cabinet to ramp door is 34’, cabinet is 2' deep.
95.5” Rear Door Opening Width
Intech Icon Package Upgrade
17.5” Alcoa wheel upgrade, Full Spare Tire and Alcoa Wheel in neck
12k Winch with Synthetic Rope mounted inside front cabinet with fairlead
Dual Batteries in neck
Dual Hydrualic Landing gear
Diamond Plate Steps to Bunk, Bunk Carpeted
50 Amp Service with Cord (No Generator)
Front roof vent Prepped for AC. Both ceiling vents are fan and electric open/close
60” Double Side Door with slide out step
Upper and Lower Cabinets
Additional Interior 12V Lights
Bluetooth Stereo with Interior and Exterior Speakers
6” additional clearance on gooseneck for extra clearance with lifted tow vehicles